Acrylamide in foods
Imprimir
Enviar por email
February 2017
Acrylamide is a well-known industrial chemical whose primary use is the synthesis of polyacrylamide. The discovery of the presence of acrylamide in food first occurred when environmental contamination from a Swedish construction project caused widespread death of livestock. Workers were tested for the content of acrylamide-haemoglobin adduct in blood samples, and low levels were unexpectedly found in the non-smoking control group of non-exposed workers. This led to investigation of food as a possible source, and the discovery that acrylamide was formed when potatoes were heated above 120̊C. Samples of commercially available foods in Sweden were then analysed and acrylamide was found in a number of foods commonly consumed, particularly carbohydrate rich foods prepared by heating at high temperature. The results were published in April 2002 (Tareke et al 2002) and the occurrence of acrylamide in foods rapidly became a global issue. The results announced in Sweden were soon confirmed in other countries, and it became evident that acrylamide has, unsuspected until 2002, been part of human diets ever since foods were first prepared by cooking. Due to acrylamide’s potential as a public health threat, both as a suspected carcinogen and a neurotoxin, many studies were rapidly initiated, with extensive cooperation/collaboration among several countries.
Following the 2002 announcement, attention became focused on the Maillard Reaction when it was discovered, that acrylamide was formed from the reaction of reducing sugars and the amino acid asparagine during heating. Formation of acrylamide is favoured by high temperatures and low moisture content; it is primarily a surface reaction, i.e. acrylamide in bread is primarily located in the crust with very low or no amounts in the crumb. One reason for the high acrylamide content of potato crisps is that a crisp is essentially two surfaces with very little matter between them.
The reducing sugars (glucose, fructose) and asparagine are natural components of plants and plant-derived ingredients. They are particularly prevalent in cereals and potatoes. It has been shown that the reducing sugars are the limiting factors in acrylamide formation in potatoes, while asparagine appears to be the limiting factor in cereal products (Stadler 2006).
Much research has focused on the human health risks of the levels of acrylamide found in foods and on ways of reducing those levels. Carcinogencity has been demonstrated in animal studies at high doses, but is unproven in humans at the acrylamide concentrations found in the diet. Reduction strategies for food manufacturers are now described in detailed Codes of Practice, with different approaches required for different food types. There is also advice available on how to minimize acrylamide during domestic cooking.
Progress is being made in the reduction of the acrylamide content of some products. No single method of reduction works universally. Reduction still must be addressed on a case-by-case or category-by-category basis. It is unlikely that it will be possible to reduce the acrylamide content in many foods without changes in the food (colour, flavour, texture) and consumer acceptability. Food safety concerns must also be considered, as also any potentially involving diet-nutrition-health consequences.
Although both gas-chromatographic and liquid-chromatographic methods were initially developed (Castle and Erickson 2005, Lehotay 2006), the majority of laboratories now use liquid-chromatography-mass spectrometry (LC-MS) methods of analysis (Tekelli 2012). Most commercial laboratories can comfortably measure to 10 µg/kg or below in even “difficult” sample types such as chocolate and coffee.
Acrylamide occurs in carbohydrate (reducing sugar)-containing foods prepared by heating above 120°C, e.g. frying, grilling, baking, broiling. Acrylamide is not present in the native (raw) ingredients (e.g. raw potato) and is not formed during boiling or microwaving (although some exceptions appear to occur for the latter). Potato and cereal food products tend to have the highest amounts of acrylamide among commonly consumed foods. Meat products are very low in acrylamide content, lacking the precursors required for its formation.
The acrylamide content of food(s) varies widely within the same food product, within the same manufacturing facility at different times, and between manufacturers (using different formulations and processing conditions). Large databases of occurrence data are maintained by the European Commission (European Union Acrylamide Monitoring Database) (European Commission 2006) and the US Food and Drug Administration (Survey Data on Acrylamide in Food: Individual Food Products) (US FDA 2006).
Based on the distribution of these occurrence data, the European Commission have recommended concentrations above which investigations should be carried out (European Commission 2013)
Potato chips (crisps) 1000 μg/kg
French fries (potato chips) 600 μg/kg
Wheat-based soft bread 80 µg/kg
Other soft bread 150 µg/kg
Breakfast cereals 200 – 400 µg/kg, dependent upon type of cereal
Gingerbread 1000 µg/kg
Other biscuits 500 µg/kg
Roast coffee 450 µg/kg
Instant coffee 900 µg/kg
Coffee substitutes 2000 – 4000 µg/kg, dependent on type
Infant food (biscuits and rusks) 200 µg/kg
Infant food (containing prunes) 80 µg/kg
Other infant food 50 µg/kg
These figures are only for guidance, since the actual acrylamide contents will vary with product, manufacturer and country. For example, the breakfast cereals data was based largely on the continental European diet, which does not include the toasted bran flake cereals popular in the UK.
Within a few months following the 2002 announcement, attention became focused on the Maillard Reaction (MR) when it was reported from England (Mottram et al), Switzerland (Stadler et al 2002) and Canada, that acrylamide was formed from the reaction of reducing sugars and the amino acid asparagine. In subsequent studies, it was confirmed that the primary mechanism of formation is the reaction of glucose and/or fructose with asparagine
during heating via the MR. Formation of acrylamide is favoured by high temperatures and low moisture content. It is primarily a surface reaction, so that acrylamide in bread is primarily located in the crust with very low or no amounts in the crumb. One reason for the high acrylamide content of potato crisps is that a crisp is essentially two surfaces with very little matter between them. As temperature increases and moisture content decreases, acrylamide formation increases. In general, the darker in colour the food product (burnt toast, darker chips), the higher the acrylamide content.
The MR is not a single reaction but a complex series of reactions occurring during the heating of reducing carbohydrates and amino acids. It is primarily responsible for the flavours, aromas and brown colours in many foods, e.g. browning during toasting and in frying potatoes. In addition to these and many other beneficial compounds, numerous compounds with potential adverse health benefits also are formed. Normally these are not consumed in sufficient amounts to be a danger to humans. However, until 2002, it was unsuspected that acrylamide was formed and has been part of human diets ever since foods were first prepared by cooking thousands of years ago.
The reducing sugars (glucose, fructose) and asparagine are natural components of plants or plant-derived ingredients used in food preparation, particularly in cereals and potatoes. Research has shown that the reducing sugars are the limiting factors in potatoes, while asparagine is the limiting factor in cereal products (Stadler 2006).
Later studies indicated that one other chemical compound (3-aminopropionamide), which can be formed during MR, can be converted to acrylamide under aqueous conditions (Schieberle et al. 2005). It is an effective precursor of acrylamide and was confirmed as a transient intermediate in its roasting (Granvogl and Schieberle 2007). It has been identified in cocoa beans, coffee and cereal products (such as popcorn). The extent to which it may be involved as an intermediate in acrylamide formation in foods is not yet known. It has been identified as a minor precursor in the formation of acrylamide in potatoes (Granvogl et al. 2004).
Estimation of acrylamide exposure from diet began shortly after the original announcement and as soon as the data required (acrylamide content of foods and the amount of each consumed) enabling a preliminary estimate could be obtained. Exposure data is normally calculated for gender, age groupings and for average (mean) and high consumers in each age group. It can be aggregated for estimation of a national average. For France, Germany, the Netherlands, Norway, Sweden, the UK and the USA acrylamide exposures range from 0.3 – 3.2 μg/kg bw-1day-1 with considerable variation in the estimations. Children may have acrylamide intakes two to three times those of an adult on a body weight basis. Even though the estimates may be done in different ways and dietary habits differ between countries, an average mean intake can be considered to be about 0.4 μg/kg bw-1day-1 and the average intake for a high-level consumer to be about 1.0 μg/kg bw-1day-1 (Mills et al 2009).
Foods contributing the most to these exposures will vary between different countries and according to the daily diet. In the US, the foods contributing the largest amount to the daily consumption include French fries (chips), potato chips (crisps), cereal products (breakfast cereal, cookies, toast, pies and cakes, crackers and bread), and brewed coffee (DiNovi 2006). In many European countries, potato products (French fries, crisps and comparable products), bread (toast and soft bread) and coffee also are major contributors.
In a small duplicate diet study in Switzerland (Swiss 2002), it was found that 8% of the daily intake of acrylamide occurred from breakfast, 21% from lunch, 22% from dinner, 13% from snacks, and 36% from coffee. These values were later corrected for an apparently low consumption of some fried foods in the study, compared to the normal diet. However, the contribution from coffee was still 22%. This illustrates the fact that just because a particular food product contains a high amount of acrylamide, it may not be a major contributor to intake if it is not consumed in large quantities. A food or diet item relatively low in acrylamide content, such as bread, can make a significant contribution to the dietary intake of acrylamide when it is consumed in larger quantities.
Acrylamide is a food problem, not that of one or a few particular foods. For example, in the US it is estimated that foods containing acrylamide contribute 38% of the daily calories, 33% of the carbohydrates, 36% of the fibre, and more than 25% of a significant number of micronutrients (Petersen and Tran 2005). This is a very important observation, particularly since so much emphasis is placed on the contribution of crisps and potato chips as sources of acrylamide in normal diets.
The primary question globally concerning potential adverse health risks from consuming the acrylamide present in foods common to the normal diet is: Does the presence of acrylamide in food and its consumption constitute a human health hazard, particularly an increase in the risk of cancer?
Toxicology:
Acrylamide is a well-known industrial chemical whose toxicological properties have been studied extensively. It has been found to be carcinogenic in animal studies, primarily rodents, with limited primate studies, using doses higher than typical human dietary exposures, as is common in such studies. The International Agency for Cancer Research (IARC) classifies acrylamide as “probably a human carcinogen” based on animal studies (IARC 1994). Acrylamide is genotoxic in a range of assays and is acutely neurotoxic. It is a known human neurotoxin. It is highly likely that exposure from consumption of acrylamide-containing food is far below the exposure required for neurotoxicity. However, the primary metabolite of acrylamide is glycidamide, an epoxide that readily reacts with DNA. This raises concerns about potential genotoxicity. However, at this time, insufficient information is available to address carcinogenicity or genotoxicity in humans from the amount of acrylamide consumed in the normal diet (EFSA 2015)
A major rat and mouse toxicological study was completed over a period of more than two years at the US National Center for Toxicological Research (NCTR). The data from this were shared with JECFA (Joint FAO/WHO Expert Committee on Food Additives) for their 2010 second risk assessment of acrylamide in foods (see JECFA 2010). In a more recent two year mouse and rat study (Beland et al 2012), the authors conclude by stating “the tumours observed in multiple organs from both sexes and species of rodents exposed chronically, coupled with previous mechanistic data, strongly support that acrylamide is a genotoxic carcinogen as a result of metabolic activation to glycidamide.”
Epidemiology:
Causes of death among a cohort of workers exposed to acrylamide (employed between 1925 and 1976) in four factories (three in the US, one in the Netherlands) were investigated (1989). Among exposed workers, mortality from all causes was significantly reduced; a weak indication of increased incidence of pancreatic cancer and Hodgkinʼs disease was observed. This same cohort, updated for the period 1984-1994, was again analyzed (1999). For the period 1925-1994, no evidence was obtained for a statistically significant excess of mortality. This led to the conclusion that there is little evidence for a causal relationship between acrylamide exposure and cancer mortality (from Dybing and Sanner 2003).
A group of six case-control and cohort epidemiological studies from the US and Italy were reported during the period 2003-2006. No evidence was found for a positive association (increased risk) between dietary intake of acrylamide and any increase in the relative risk of the cancers studied: large bowel, kidney, bladder, renal cell, oral cavity and pharynx, esophagus, larynx, and ovary. This group of studies has been reviewed (Mucci and Wilson 2008). No differences were observed in associations among smokers and non-smokers, although smoking is an important source of exposure to acrylamide. The sensitivity of the results from these studies has been criticized due to the relatively small number of subjects. It is believed that this would not yield the discriminatory power required to detect the small increases in cancer risk that might be anticipated from consumption of the amount of acrylamide encountered in foods comprising the normal diet.
Three prospective case-control cohort studies from the Netherlands used a larger number of subjects (Hogervorst et al 2007, Hogervorst et al 2008a, Hogervorst et al 2008b). Findings from these studies include:
- Increased risks of postmenopausal endometrial and ovarian cancer with increasing intake of acrylamide among never-smokers.
- Acrylamide intake was not associated with breast cancer.
- No positive associations were found between acrylamide intake and increased risk of bladder and prostate cancer.
- However, the authors reported some indications for a positive association between intake of dietary acrylamide and renal cell cancer risk.
- Acrylamide intake was not associated with colorectal, gastric, pancreatic and esophageal cancer risk, but some subgroups deserve further attention.
The preponderance of these epidemiological studies show no correlation between consumption of acrylamide containing foods and increased risk for a number of cancers. However, it is clear that some differences exist in findings between the studies. It is considered unlikely that epidemiological evidence will be able to prove or disprove an association between consumption of acrylamide-containing foods and an increased risk of cancer, i.e. a cause-effect relationship.
The US National Cancer Institute has issued a report on Acrylamide in Food and Cancer Risk (US National Cancer Institute, 2013).
In 2005, the Joint Expert Committee on Food Additives (JECFA) conducted a risk assessment of acrylamide in foods (JECFA 2005). Analytical data on the occurrence of acrylamide in foods from different countries was obtained from 24 countries with most of the samples from Europe (67.6%) and the US (21.9%); the remainder were from Asia (8.9%) and the Pacific (1.6%). No analytical data were received from Latin America and Africa.
The Committee recommended that:
1. Acrylamide be re-evaluated when results of ongoing carcinogenicity and long-term neurotoxicity studies become available.
2. Work should be continued on using pharmacologically based pharmacokinetic modelling to better link human biomarker data with exposure assessments and toxicological effects in experimental animals.
3. Appropriate efforts to reduce acrylamide concentrations in food should continue.
4. In addition, the Committee noted that it would be useful to have occurrence data on acrylamide in foods as consumed in developing countries. This information will be useful in conducting intake assessments as well as considering mitigation approaches to reduce human exposure.
With additional data available on occurrence, mitigation, and dietary exposure together with the data previously considered in 2005 (JECFA 2005), new epidemiological studies, and results from recently completed toxicological studies (metabolism, genotoxicity, neurodevelopmental and long-term carcinogenicity), JECFA conducted the second risk assessment at its 72nd Meeting (Rome, 16–25 February 2010). A Summary and Conclusions report was reissued on 16 March 2010 (JECFA 2010) with the final report to be published in the next several months. Conclusions and comments, as taken/quoted from the report, include:
1. Since 2003, mitigation efforts have been reported “for food types with high acrylamide levels or single products with higher levels than those within a food type.” While this may “significantly reduce exposure for some individuals or population subgroups,” it “will have little effect on the average dietary exposure for the general population.” This essentially validates and is consistent with early comments that reducing the acrylamide content in or eliminating any one food product will have no impact on overall exposure to acrylamide.
2. The estimated average dietary exposure acrylamide exposure for the general population and the exposure for consumers with high dietary exposure had not changed since the 2005 JECFA meeting.
3. “While adverse neurological effects are unlikely at the estimated average exposure, morphological changes in nerves cannot be excluded for individuals with a high dietary exposure to acrylamide.ʼ This is consistent with the observations made in 2005.
4. ʻʼFor a compound that is both genotoxic and carcinogenic,” results from toxicology studies in rats and mice are indicative of a health concern. The extensive new data from the cancer bioassays in mice and rats support the previous evaluation (JECFA 2005).
5. It was also noted that “worker cohort epidemiological studies did not provide any evidence that exposure to acrylamide resulted in an increase in the incidence of cancer.”
6. “There was a poor correlation between the estimated dietary exposure and internal biological markers of acrylamide exposure adducts in humans.” To better estimate the cancer risk from acrylamide in food for humans, it was recommended that longitudinal studies on intra-individual levels of acrylamide and glycidamide hemoglobin adducts be measured over time in relation to concurrent dietary exposure. This would provide a better estimate of exposure to acrylamide for subsequent epidemiological studies.
The comments and conclusions essentially indicate that the 2005 Risk Assessment is still valid and the findings are consistent with the language used at that time. It is anticipated that the final recommendations probably will include that regulators continue to develop risk management approaches to reduce acrylamide formation in food. This would be consistent with the approach that currently is being used in many countries and reflects an ALARA (as low as reasonably achievable) approach. The inherent difficulty with this approach is: who determines/defines what ʻreasonablyʼ is?
Beginning shortly after the announcement in Sweden, there have been extensive studies devoted to the reduction of acrylamide in foods where possible without changing consumer acceptability of the resulting food product or increasing food safety concerns or introducing unintended increased public health risk (for example, increased fat content of chips through frying at a lower temperature) . Much of this work has been done in the food industries, but also has involved academic and government scientists/technologists. Members of the European food industry freely shared the results of their studies through a collaboration coordinated by the Confederation of the Food and Drink Industry of the EU (CIAA) (now known as FoodDrinkEurope, FDE).
Reduction/mitigation of acrylamide in foods can be approached through (a) removing reactants (fructose, glucose, asparagine) before the heating process, (b) disrupting the reaction (addition of amino acids, food grade acids, changing reaction conditions) and (c) removing acrylamide after its formation during heat processing. The latter approach has not proved to be viable.
Different approaches are required for different types of food and processes; there is no one-size-fits-all solution. Efforts, ranging from laboratory through industrial scale, have focused on (a) changing ingredients (decreasing glucose, fructose, asparagine), (b) altering processing conditions (lower heating temperatures, decreased heating time, blanching, use of the enzyme asparaginase), (c) changes in equipment, and (d) agronomic practices (for example storage practices, breeding of cultivars with lower glucose, fructose and/or asparagine content, selection of current cultivars with lower glucose, fructose and/or asparagine contents). Some approaches that have been used to reduce acrylamide formation in the laboratory or pilot plant, have not yet been successfully scaled to industrial production.
A relatively recent development has been the use of the enzyme asparaginase, which converts asparagine to aspartic acid. The latter cannot form acrylamide. Asparaginase is commercially produced from Aspergillus niger (DSMʼs Preventase) or Aspergillus oryzae (Novozymeʼs Acrylaway). Both have been approved in several countries for use in reducing acrylamide in selected food products. They are particularly effective in dough products (e.g. cereal products or fabricated chips), but can be applied in soaking (blanching) (e.g. potato strips) where they can reduce asparagine concentrations on the surface. Reduction of acrylamide contents in selected products made from doughs has ranged up to over 90%. The use of asparaginase is included in the FDE Acrylamide Toolbox (FDE 2013).
After several years of cooperative research and testing, the results were compiled into the CIAA Acrylamide ʻToolbox,” first released in 2005 (CIAA 2009a) giving descriptions of intervention steps that have been tried, evaluated, and have been successful in reducing acrylamide formation in specific classes of products. It warns where intervention steps have the potential for producing decreased product quality or acceptance. The Toolbox is meant for individual manufacturers including small and medium size industries. It can also provide useful leads for catering, retail, restaurants, and domestic cooking to aid in the reduction of acrylamide. It allows potential users to access, assess and evaluate which reduction measures are appropriate for their product(s). Most of these intervention steps have already been implemented commercially.The FoodDrinkEurope Toolbox is free to download (FDE 2013). The most recent draft (May 2016) is a much more detailed Code of Practice. It is yet to be issued, but a draft is available online (FDE 2017). This delay is because the European Commission are consulting on making adoption of the FDE Code of Practice mandatory. Legislation to this effect is expected in 2017. As well as mandatory mitigation steps, the draft CoP includes a requirement for food producers to monitor acrylamide levels in their own products. To pre-empt legislation, the draft has been widely circulated and is in use by many food manufacturers.
An important consideration for food producers is that acrylamide exposure applies to food as-consumed. Therefore manufacturers of cook-at-home products, such as pizzas or ready-to-roast potatoes, need to validate their on-pack cooking instructions as part of their acrylamide mitigation strategy.
In terms of global trade, the Codex Alimentarius Commission (CAC) adopted a Code of Practice for the Reduction of Acrylamide in Foods in July 2009 (CAC 2009). This Code of Practice is intended to provide national and local authorities, manufacturers and other relevant bodies with guidance to prevent and reduce formation of acrylamide in potato products and cereal products. The guidance covers three strategies (where information is available) for reducing acrylamide formation in particular products. The use of the three strategies, similar to those mentioned above should enable nations and their food processing organisations to facilitate mitigation/reduction of acrylamide in those food products where it is possible without loss of consumer acceptance of the product or generation of additional food safety or health concerns. Likewise the US FDA is considering issuing guidance concerning the reduction of acrylamide content in foods. As part of this process, it has requested comments and data from the food industry on practices they have adopted for their products and what reductions they have achieved (US FDA 2009).
Catering and take-away food is one sector where there has been less focus on acrylamide mitigation. A recent research review (Parker et al. 2012) describes measures for reducing the formation of acrylamide in preparing frozen, part-fried potato strips -- distributed to some food outlets for making french fries.
As of this time (February 2017) the European Commission are consulting on a proposal to make the FDE Code of Practice for Managing Acrylamide Formation in Foods mandatory for food business operators. This proposal is broadly supported by industry and by Member States, and legislation is expected in 2017. The proposal follows prolonged discussions as to whether acrylamide controls should be based upon maximum concentration levels or upon a mitigation (Code of Practice) approach, and whether controls should be recommendations or legally binding. The proposal is for a legally binding Code of Practice.
The draft Code of Practice has been circulated since January 2016 and, irrespective of the legislation, is used by some food manufacturers as a best practice guide.
The concentration of acrylamide recommended (European Commission 2013) to trigger investigations are still relevant, with caveats about differences in different national diets, and are taken as a useful benchmark for many food types.
Prior to this, Germany has been the only nation that has adopted a formal scheme as a goal/recommendation concerning acrylamide limits in foods. This system, known as the German Minimization Concept, does not have regulatory status but is a voluntary system of collaboration between the government and the food industry. Foods are classified into certain food groups. Data concerning the amount of acrylamide in a food product are collected from official surveillance laboratories of the federal states and the Federal Institute of Risk Assessment. The products which constitute the top 10% of acrylamide content in each food group are identified. The lowest value among that 10% is the ʻsignal valueʼ for the group. This is the goal for reduction of acrylamide content of the products in that 10%. Data on acrylamide content for that category is collected annually and the listing again prepared. If the signal value is greater than 1,000 μg/kg, it will then automatically remain at that value (i.e., 1,000 μg/kg). The Signal Value is then recalculated (annually). It can only be decreased, not increased. This practice has been in progress since the first values were set in late 2002. At that time, a decision was made that all food products with an acrylamide content of 1,000 μg/kg or greater should, in principle, be included in the reduction efforts. Some successes have resulted, but a number of the products have not been successful in meeting the signal value. The Signal Value for breakfast cereals, bakery wares, specialty biscuits, French fries (prepared), potato patties, and roasted coffee beans have been reduced from 2002 values to those listed for the Seventh calculation (2008). No progress has been made in lowering the Signal Value of 1000 for potato crisps or gingerbread. The system has been modified to include an ʻobserved value.ʼ This is calculated basically in the same way as the signal value, but without the condition that it must not be increased and must not exceed 1,000 μg/kg. In several cases, the observed value within a food category remained above the signal value in the 2008 listing..
As a result of recent evaluations of acrylamide as an industrial chemical, some recommendations have been made that can impact concerns about acrylamide in foods. The evaluations were part of a process being undertaken, particularly in the EU, Canada and the USA to review a much larger listing of chemicals that are used commercially.
1. The European Chemicals Agencyʼs (ECHA) Member State Committee identified acrylamide as one of 15 new chemicals for the Candidate List of substances of very high concern (SVHC) (ECHA 2009). Acrylamide has been included in that list (ECHA 2010).
2. The US Department of Health and Human Servicesʼ (DHHS) Agency for Toxic Substances and Disease Registry (ATSDR) has called for public comments concerning a Draft Toxicological Profile for acrylamide, “a toxic substance produced during heating of certain foods.” The profile “provides interpretation of available toxicological and epidemiological information and identification of toxicological testing needed to identify the types or levels of exposure that may present significant risk of adverse health effects to humans” (ATSDR 2009).
3. Acrylamide was one of 19 substances included in Batch 5 of the Chemicals Management Plan of Canada. This is part of Canadaʼs continuing review of about 200 chemicals of widespread industrial use that have not been through a thorough risk analysis. When the final screening assessments and proposed risk management plans was released, it was recommended that acrylamide be added to the governmentʼs list of toxic chemicals. The decision to do so means that the Government of Canada will have to take steps to ensure that exposure of its citizens to acrylamide from food sources is kept as low as possible (ALAP). A three pronged management approach to achieving this has been initiated and includes (a) working with the food industry to develop and implement acrylamide reduction strategies that can be used by food processors and the food service industry, (b) regularly updating consumption advice, and (c) working with international partners (EU, US, Japan) to coordinate risk management efforts (Government of Canada 2009).
These conclusions are not surprising since acrylamide, as an industrial chemical, is recognized as a probable human carcinogen, an animal genotoxin, and neurotoxin.
Recommendations have essentially been to maintain the diets currently recommended by the national health agency of the country. For the US, the FDA recommendation has been and continues to be that the public eat a balanced diet, choosing a variety of foods that are low in trans fat and saturated fat, and rich in high-fibre grains, fruits, and vegetables. The US Environmental Protection Agency (USEPA) recommendation is:
(a) Avoid eating a lot of carbohydrate-rich foods that are cooked at high temperatures (e.g. French fries).
(b) Foods with higher protein content appear to have lower amounts of acrylamide.
(c) Avoid overcooking foods.
Dietary recommendations from other countries are similar to these. The Norwegian government, however, went further by recommending a decrease in consumption of potato crisps for those consumers who consume excessive amounts. The UK Food Standards Agency (FSA) does not currently recommend consumers to avoid consuming foods high in acrylamide, but offers advice on minimising acrylamide formation on home-cooking (UK FSA, 2017). The FSA Chief Scientific Advisor's 2015 Science Report (Issue 2) considered household studies aimed at providing information on actual domestic cooking and preparation practices in the UK to inform this issue, through: identifying the practices in which consumers are engaging that might influence acrylamide formation; and providing an indication as to how much acrylamide consumers are exposed to from food prepared at home. In USA, the FDA has issued advice to consumers on “how to help cut acrylamide in your diet” (US FDA, 2013b).It has also issued a general web page on Acrylamide Questions and Answers (US FDA, 2013a).
Thus, progress is being made in the reduction of the acrylamide content of some products. No single method of reduction works universally. Reduction still must be addressed on a case-by-case or category-by-category basis. It is unlikely that it will be possible to reduce the acrylamide content in many foods without changes in the food (colour, flavour, texture) and consumer acceptability. Food safety concerns must also be considered, as also any potentially involving diet-nutrition-health consequences.
--
ATSDR (Agency for Toxic Substances and Disease Registry) (2009) Toxicological profiles "Draft for Public Comment"- CERCLA Set 23 http://www.atsdr.cdc.gov/toxprofiles/tp203.html
Beland, FA et al., (2012). Carcinogenicity of acrylamide in B6C3F1 mice and F344/N rats from a two-year drinking water exposure, Food and Chemical Toxicology, 50 (11), In Progress (November 2012): Available online 23 September 2012 http://www.sciencedirect.com/science/article/pii/S0278691512006904?v=s5
CAC (2009) Code of Practice for the Reduction of Acrylamide in Foods (CAC/RCP 67-2009) http://www.codexalimentarius.net/download/standards/11258/CXP_067e.pdf
Council for Agricultural Science and Technology (CAST), 2006, Acrylamide in Food, Issue Paper No. 32, Council for Agricultural Science and Technology (CAST), Ames, IA, USA. http://www.castscience.org/websiteUploads/publicationPDFs/acrylamide_ip.pdf
Castle, L. and S. Eriksson (2005) Analytical Methods Used to Measure Acrylamide Concentrations in Foods, J. AOAC Intʼl, 88:274-284. http://www.atypon-link.com/AOAC/doi/abs/10.5555/jaoi.2005.88.1.274
Castle, L. (2006) Analysis for acrylamide in foods, In “Acrylamide and other hazardous compounds in heat treated foods,” K. Skog and J. Alexander (Eds), Woodhead Publishing, Cambridge, UK, Chapt. 6, pp 117-131.
Dybing, E. and Sanner T (2003) FORUM: Risk Assessment of Acrylamide in Foods, Toxicological Sciences, 75:7-15 http://toxsci.oxfordjournals.org/cgi/reprint/75/1/7
DiNovi M (2006) The 2006 Exposure Assessment for Acrylamide (Power Point), http://www.fda.gov/downloads/Food/FoodSafety/FoodContaminantsAdulteratio...
ECHA (European Chemicals Agency) Press Release (2009) 15 New substances of very high concern to be added to the Candidate List. http://echa.europa.eu/doc/press/pr_09_15_msc_svhc_20091207.pdf
ECHA (European Chemicals Agency) Press Release (2010) Acrylamide included in the REACH Candidate List of Substances of Very High Concern for Authorisation.
http://echa.europa.eu/doc/press/pr_10_05_acrylamide_20100330.pdf
EFSA Panel on Contaminants in the Food Chain (2015) Scientific Opinion on Acrylamide in Food, EFSA Journal 13:4104
European Commission (2006) European Union Acrylamide Monitoring Database, http://ec.europa.eu/food/safety/chemical_safety/contaminants/catalogue/a...
European Commission (2013) Commission Recommendation of 8 November 2013 on investigations into the levels of acrylamide in food (2013/647/EC)
European Food Safety Agency (June 2015). Scientific Opinion on Acrylamide in Food. http://www.efsa.europa.eu/en/efsajournal/pub/4104.htm
FoodDrinkEurope, (2013): Acrylamide Toolbox. http://www.fooddrinkeurope.eu/uploads/publications_documents/AcrylamideT...
FoodDrinkEurope (2017): https://corporateeurope.org/sites/default/files/attachments/aafooddrinkeurope_copsupdated_280616cleanonetemplate.pdf (accessed 9 February 2017)
Friedman M and Mottram D (Eds), 2005, “Chemistry and Safety of Acrylamide in Food,” Advances in Experimental Medicine and Biology, Vol. 561, Springer, New York, NY, USA.
Government of Canada (2009) The Government of Canada Completes Assessments for an Additional 19 Substances Included in the Chemicals Management Plan http://www.marketwire.com/pressrelease/Government-Canada-Completes-Assessments-Additional-19-Substances-Included-Chemicals-1034350.htm
Granvogl, M et al. (2004) Quantitation of 3-Aminopropionamide in Potatoes – A Minor but Potent Precursor in Acrylamide Formation, J. Agric. Food Chem. 52:4751-4757. http://pubs.acs.org/doi/abs/10.1021/jf049581s
Granvogl, M and Schieberle P (2007) Quantification of 3-aminopropionamide in cocoa, coffee and cereal products, European Food Research and Technology 225:857-863. http://www.springerlink.com/content/776qq3p7k3411804/?p=c0a121c3003e4bf2...
HEATOX. Heat-generated food toxicants: identification, characterization and risk minimization (HEATOX), Final Report http://www.slv.se/upload/heatox/documents/Heatox_Final%20_report.pdf
Hogervorst, JG et al. 2007. A Prospective Study of Dietary Acrylamide Intake and the Risk of Endometrial, Ovarian and Breast Cancer. Cancer EpidemiolBiomarkers Prevention 16:2304-2313. http://cebp.aacrjournals.org/content/16/11/2304.full?sid=8c08948ea05a-46...
Hogervorst, J G et al. 2008a, Dietary acrylamide intake and the risk of renal cell, bladder, and prostate cancer, Am J. Clin. Nutr. 87:1428-1438. http://www.ajcn.org/cgi/content/full/87/5/1428
Hogervorst, J G et al., 2008b. Dietary Acrylamide Intake Is Not Associated with Gastrointestinal Cancer Risk. J. Nutr. 138:2229-2236. http://jn.nutrition.org/cgi/content/abstract/138/11/2229?maxtoshow=&hits...
IARC. 1994. IARC Monographs on the evaluation of carcinogen risk to humans: some industrial chemicals, No. 60. 1994, Lyon, International Agency for Research on Cancer. http://monographs.iarc.fr/ENG/Monographs/vol60/mono60-16.pdf
International Union of Food Science & Technology (IUFoST), 2010. Scientific Information Bulletin on Acrylamide in Foods. http://www.iufost.org/sites/default/files/docs/IUF.SIB.AcrylamideinFoods.pdf
JECFA (Joint FAO/WHO Expert Committee on Food Additives), Sixty-fourth meeting, Rome, 8-17 February 2005, Summary and Conclusions, pp. 7-17 ftp://ftp.fao.org/es/esn/jecfa/jecfa64_summary.pdf
JECFA (Joint FAO/WHO Expert Committee on Food Additives), Seventy-second meeting, Rome, 16-25 February 2010, Summary and Conclusions pp 2, 7-8 http://www.fao.org/ag/agn/agns/jecfa/JECFA72%20Summary%20Version%2016%20...
Lehotay, S, Mastovska, K, 2006, Rapid Sample Preparation Method for LC-MSMS or GC-MS Analysis of Acrylamide in Various Food Matrices, J Agric Food Chem, 54: 7001-7008
Mills, C et al., 2009. Acrylamide, Chapter 2.1, in “Process-Induced Food Toxicants: Occurrence, Formation, Mitigation, and Health Risks,ʼ R. H. Stadler and D. R. Lineback (Eds), pp 23-50, John Wiley & Sons, Hoboken, N.J., USA
Mottram, D S et al., 2002, Acrylamide is formed in the Maillard reaction, Nature, 419:448-449. http://www.nature.com/nature/journal/v419/n6906/full/419448a.html
Mucci, L A. and Wilson E M, 2008, Acrylamide Intake through Diet and Human Cancer Risk, J. Agric. Food.Chem. 56:6013-6019. http://pubs.acs.org/doi/abs/10.1021/jf703747b
Parker, J K et al. (2012)/ Kinetic Model for the Formation of Acrylamide during the Finish-Frying of Commercial French Fries. Journal of Agricultural and Food Chemistry, 2012; 60 (36): 9321 DOI: 10.1021/jf302415n http://www.sciencedaily.com/releases/2012/09/120926123804.htm?utm_source=feedburner&utm_medium=feed&utm_campaign=Feed%3A+sciencedaily+%28ScienceDaily%3A+Latest+Science+News%29
Petersen, B J. and Tran N, 2005, Chapter 3: Exposure to Acrylamide In “Chemistry and Safety of Acrylamide in Food,” Advances in Experimental Medicine and Biology, Vol. 561, pp. 63-76, Springer, New York, NY, USA.
Schieberle, P et al (2005) New Aspects on the Formation and Analysis of Acrylamide, In “Chemistry and Safety of Acrylamide in Food,” M. Friedman and D. Mottram (Eds.), Advances in Experimental Medicine and Biology. 561:205-222, Springer, New York, NY, USA.
Skog K and Alexander J (Eds), 2006. “Acrylamide and other hazardous compounds in heat-treated foods,” CRC Press, Baton Rouge, FL, USA
Stadler, R H. (2006) The formation of acrylamide in cereal products and coffee, In “Acrylamide and other hazardous compounds in heat-treated foods,” K. Skog and J. Alexander (Eds), Woodhead Publishing, Cambridge, UK, Chapt. 2, pp 23-40.
Stadler, R H et al., Acrylamide from Maillard reaction products, Nature, 419:449-450. http://www.nature.com/nature/journal/v419/n6906/full/419449a.html
Swiss, 2002, Swiss Federal Office of Public Health Assessment of acrylamide intake by duplicate diet study. http://www.bfr.bund.de/cm/208/assessment_of_acrylamide_intake_by_duplica...
Tareke, E et al. 2002, Analysis of acrylamide, a carcinogen formed in heated foodstuffs. J. Agric. Food. Chem. 50:4998-5006. http://pubs.acs.org/doi/abs/10.1021/jf020302f
Tekkeli, E et al, 2012, A Review of Current Methods for the Determination of Acrylamide in Food Products, Food Analytical Methods, 5: 29-39
UK FSA (2015) Food Standards Agency Chief Scientific Advisor’s report on Acrylamide https://www.food.gov.uk/sites/default/files/csa-acrylamide-report.PDF
UK Food Standards Agency, 2017; Acrylamide. https://www.food.gov.uk/science/acrylamide-0
US FDA (United States Food and Drug Administration), 2006, Survey Data on Acrylamide in Food: Individual Food Products. http://www.fda.gov/Food/FoodSafety/FoodContaminantsAdulteration/ChemicalContaminants/Acrylamide/ucm053549.htm
Request for Comments and for Scientific Data and Information. http://www.thefederalregister.com/d.p/2009-08-26-E9-20495
US FDA, 2013a: Acrylamide Questions and Answers: http://www.fda.gov/Food/FoodborneIllnessContaminants/ChemicalContaminants/ucm053569.htm
US FDA, 2013b: For Consumers: You can help cut acrylamide in your diet. http://www.fda.gov/ForConsumers/ConsumerUpdates/ucm374855.htm
US National Cancer Institute, 2013: Acrylamide in Food and Cancer Risk http://www.cancer.gov/cancertopics/causes-prevention/risk/diet/acrylamide-fact-sheet
US National Toxicology Program, 2012. Toxicology and Carcinogenisis Studies of Acrylamide (CAS No. 79-06-1) in FN344N Rats and B6C6F1 Mice, Feed and Drinking Water Studies. http://ntp.niehs.nih.gov/ntp/htdocs/LT_rpts/TR575_508.pdf
Vesper H W et al. (2010). Use of haemoglobin adducts of acrylamide (HbAA) and glycidamide (HbGA) to estimate human exposure to acrylamide http://www.ncbi.nlm.nih.gov/pmc/articles/PMC2831930/
The Institute of Food Science & Technology has authorised the publication of the following updated Information Statement on Acrylamide in Food, dated February 2017, replacing that of June 2015 prepared by Prof J Ralph Blanchfield MBE. This updated Information Statement has been prepared by John Points, on behalf of, and approved by, the IFST Scientific Committee.
Fuente: http://www.ifst.org/